IDENTITY:
SAFETY DATA SHEET
SLU-PRIMER
SDS No. 1.1.3.5
Date prepared: MARCH 2011 Date revised: JANUARY 2019 .
SDS No.1.1.3.5
Section 1 – Product Identification IDENTITY:
Product Name: Chemical Characterization: Product Use Description:
Acrylic Copolymer Acrylic Latex Primer
AQUAFIN, INC. 505 BLUE BALL RD. #160 ELKTON, MD 21921
24 hr Emergency Phone: Chem-Tel (800) 255-3924
Recommended use of the chemical and restriction on use:
Refer to the product technical data sheet. For industrial and professional users.
Information Phone No.
info@aquafin.net
(410) 392-2300
www.aquafin.net
Section 2 – Hazards Identification GHS Classification: Skin irritation, Category 3 Serious eye irritation, Category 2B
H316: Causes mild skin irritation. H320: Causes eye irritation.
GHS Label element: Hazard Pictograms GHS07 Signal Word:
Warning
Hazard Statements: H302: H316: H320:
Harmful if swallowed. Causes mild skin irritation. Causes eye irritation.
Precautionary Statements: Prevention: P264: Wash skin thoroughly after handling. P280: Wear protective gloves/protective clothing/ eye protection/face protection. Response: P302 + P352: P304 + P340:
P308 + P313 P332 + P313: P362:
Wash with plenty of soap and water. Remove victim to fresh air and keep at rest in a position comfortable for breathing. IF IN EYES: Rinse cautiously with water for several minutes. Remove contact lenses, if present and easy to do. Continue rinsing. IF exposed or concerned, get medical advice/attention. IF skin irritation occurs, get medical advice/attention. Take off contaminated clothing and wash before reuse.
Storage: P403 + P232:
Store in a well-ventilated place. Protect from moisture.
P305 + P351 + P338:
IF ON SKIN: IF INHALED:
Page 1 of 5
Disposal: P501: P502:
Dispose of contents/container to an approved waste disposal site. Refer to manufacturer/supplier for information on recovery/recycling.
Section 3 – Composition / Information on Ingredients Hazardous Components CAS No. Water based acrylic copolymer dispersion No hazardous components (VOC = 0 g/L)
OSHA PEL
ACGIH TLV
N.A.
Percent
There are no additional ingredients present which, within the current knowledge of the supplier and in the concentrations applicable, are classified as hazardous to health or the environment and hence not require reporting in this section.
Section 4 – First Aid Measures Inhalation:
Supply fresh air and consult a physician in case of symptoms.
Ingestion:
Drink copious amounts of water and provide fresh air. Consult a physician immediately. Do not induce vomiting without medical advice. If a person vomits, place him/her in the recovery position. Never give anything by mouth to an unconscious person.
Skin Contact:
Rinse skin with warm water. Seek medical attention if irritation persists. Wash contaminated clothing before reuse
Eye Contact:
Immediately flush eyes with plenty of water for at least 15 minutes, lifting upper and lower eyelids occasionally and consult a physician.
Section 5 – Fire Fighting Measures Auto ignition Temperature:
Not combustible.
Hazardous combustion Products:
Carbon monoxide (CO) Carbon dioxide (CO2)
Extinguishing Media:
Water, foam, CO2, extinguishing powder or water mist – Product is not combustible.
Special Fire Fighting Procedures:
In the event of a fire, wear full protective clothing and NIOSHapproved self-contained breathing apparatus with full face-piece operated in the pressure demand or other positive pressure mode.
Unusual Fire and Explosion Hazards: Containers can build up pressure if exposed to heat (fire). Cool closed containers exposed to fire with water spray.
Section 6 – Accidental Release Measures Measures for Cleaning/Collecting:
Wear appropriate protective equipment (see section 8). Contain and collect spillage with absorbent materials, i.e. sand, earth, vermiculite, diatomaceous earth, acid and universal binders, sawdust, and place in container for disposal. Rinse residual stain with water. Prevent material from reaching sewage and drainage systems or bodies of water.
Section 7 – Handling and Storage Handling:
Avoid contact with skin, eyes and clothing. Keep out of reach of children. Keep away from heat and direct sunlight. Do not store open containers. No special measures required. Page 2 of 5
Storage:
No special storage precautions needed. Store in original container, away from foodstuffs. Store containers tightly closed in a cool (frost free), well ventilated place.
Section 8 – Exposure Controls / Personal Protection General Information:
Eye-wash bottle must be available. The product does not contain any relevant quantities of materials that have to be monitored at the workplace.
Engineering Controls:
Provide good (mechanical) room ventilation to control any air contaminants.
Respiratory Protection:
Not generally required if room is well ventilated. In case of insufficient ventilation wear suitable respiratory equipment. When workers are facing concentrations above the exposure limit they must use NIOSH approved respirators.
Skin Protection:
When installing, wear appropriate protective gloves (butyl, rubber) to prevent hand-skin exposure. Wear appropriate impervious clothing to prevent skin exposure (long sleeve shirt and long pants).
Eye Protection:
Wear tightly sealed safety glasses with side shields or goggles. Face shield as necessary.
Work/Hygienic Practices:
Handle using good industrial hygiene and safety practices. Keep work area clean. Wash hands before breaks and after work, and before eating, drinking or smoking.
Section 9 – Physical and Chemical Properties Physical State: Color: Odor: Solubility in water: Flash Point: Lower explosion Limit: Upper explosion Limit: o pH-value at 20 C: Boiling Point: Freezing Point: Specific Gravity (Density): o Viscosity, dynamic at 20 C: VOC Concentration as applied:
Milky Liquid White or color pigmented Weak, characteristic like acrylic Fully miscible Not combustible N/A N/A 8 – 10 o o 212 F (100 C) Water o o 32 F (0 C) o o 1.06 kg/L at 73 F (23 C) 800 – 1,000 cps (mPas) 0 g/L
Section 10 – Stability and Reactivity Thermal Decomposition:
No decomposition if used as prescribed.
Chemical Stability:
Stable under normal temperatures and pressures.
Hazardous Polymerization:
Will not occur under normal conditions.
Incompatibilities:
None known.
Page 3 of 5
Section 11 – Toxicological Information Product Information: Acute Oral Toxicity: • LD/LC50 values that are relevant for classification:
No data existing.
Primary irritant effect: • On the skin: No irritant effect. • On the eye: No irritant effect. • Sensitization: No sensitizing effect known. • Additional toxicological information: The toxicological data are given by analogy. According to experience, the product is considered to be harmless to health if used in the correct manner. On the basis of the product’s composition, no acute general toxic effects are to be expected. Frequent contact can lead to skin and eye irritation, especially if product is allowed to dry out.
Section 12 – Ecological Information Ecological Information:
The product is a slight water pollutant. Large quantities may be toxic to fish. Do not empty into waterways and drains.
Section 13 – Disposal Considerations Recommendations:
Use excess product in an alternate beneficial application. Smaller quantities can be disposed with household garbage. Expose liquid product to fresh air to allow water to evaporate. Remaining cured product becomes a rubbery harmless mass.
Disposal:
Dispose of in a manner consistent with federal, state and local regulations. Empty containers should be taken to an approved waste handling site for recycling or disposal.
Cleaning Solution:
Water. If necessary, add cleaning agents (i.e. soap, etc.).
RCRA Hazardous Waste:
No.
RCRA number: NONE.
Section 14 – Transport Information DOT (Domestic Surface) Hazard Class or Division: IMO (Ocean) Hazard Class or Division: ICAO (Air) Hazard Class or Division:
Not regulated, not dangerous goods. Not regulated, not dangerous goods. Not regulated, not dangerous goods.
Section 15 – Regulatory Information TSCA Status:
There are no TSCA 12(b) Chemicals in this product.
SARA 311/312 Hazard Categories: • Reactive Hazard: No • Pressure Hazard: No • Fire Hazard: No • Immediate/Acute: No • Delayed/Chronic: No
Page 4 of 5
SARA 313 Notification:
This product contains no toxic chemicals subject to the SARA 313 supplier notification requirements.
CERCLA:
No CERCLA chemicals exist in this product above reportable concentrations.
California Proposition 65:
This product does not contain any chemicals known to the State of California to cause cancer, birth defects, or other reproductive harm.
Section 16 – Other Information (Hazard Rating:
0 = Minimal;
HMIS III rating: Health: 1* Flammability: 1
1 = Slight;
2 = Moderate;
Physical hazard: 0
3 = Serious;
4 = Severe; * = Chronic)
Protection: B
Abbreviations and acronyms: USDOT: IMDG: IATA: CAS: LC50: LD50:
United States Department of Transportation. International Maritime Code for Dangerous Goods. International Air Transport Association. Chemical Abstracts Service (Division of the American Chemical Society). Lethal concentration, 50 percent. Lethal dose, 50 percent.
SDS prepared by:
Aquafin product safety department.
DISCLAIMER: We believe the statements, technical information and recommendations contained herein are reliable, but they are given without warranty or guarantee of any kind, expressed or implied, and we assume no responsibility for any loss, damage, or expense, direct or consequential, arising out of their use. Aquafin shall not be responsible for the use of this product in a manner to infringe on any patent or any other intellectual property rights held by others. END OFsafety MSDS (April 09, 2015) User is responsible for determining appropriate measures and for applying the legislation covering his own activities. We recommend that user makes tests to determine the suitability of a product for its particular purpose prior to use. (January 22, 2019)
Page 5 of 5