SDS_AQUAFIN-MORTAR-Crete-CI_031219.pdf
5 Pages
206 KB
Download
<h1>SDS_AQUAFIN-MORTAR-Crete-CI_031219.pdf</h1> <p>IDENTITY:</p> <p>SAFETY DATA SHEET</p> <p>MORTAR-Crete-CI</p> <p>Date prepared: <br />Date revised:</p> <p>SDS No. 1.MCC.15</p> <p>APRIL 2015 <br />MARCH 2019</p> <p>SDS No.1.MCC15</p> <p>Section 1 – Product Identification <br />IDENTITY:</p> <p>Product Name:</p> <p>MORTAR-Crete-CI</p> <p>Chemical Characterization: <br />Product Use Description:</p> <p>Cement – Preparation <br />Structural Full Depth Repair Mortar</p> <p>AQUAFIN, INC. <br />505 BLUE BALL RD. #160 <br />ELKTON, MD 21921</p> <p>Emergency Phone No. <br />Information Phone No.</p> <p>info@aquafin.net</p> <p>www.aquafin.net</p> <p>(800) 394-1410 <br />(410) 392-2300</p> <p>Section 2 – Hazards Identification <br />GHS Classification: <br />Skin irritation, Category 2 <br />Serious eye damage, Category 1 <br />Respiratory system; Category 3 <br />Carcinogenity, Category 1A</p> <p>H315: <br />H318: <br />H335: <br />H350:</p> <p>Causes skin irritation (alkaline when moistened) <br />Causes serious eye damage <br />May cause respiratory irritation <br />May cause cancer</p> <p>GHS Label element: <br />Hazard Pictograms <br />GHS05</p> <p>GHS07</p> <p>GHS08</p> <p>Signal Word:</p> <p>Danger</p> <p>Hazard Statements: <br />H315: <br />H318: <br />H335: <br />H350:</p> <p>Causes skin irritation (alkaline when moistened). <br />Causes serious eye damage. <br />May cause respiratory irritation. <br />May cause cancer.</p> <p>Precautionary Statements: <br />Prevention: <br />P264: <br />Wash skin thoroughly after handling. <br />P280: <br />Wear eye protection/face protection. <br />P280: <br />Wear protective gloves. <br />P281: <br />Use protective equipment as required. <br />Response: <br />P302 + P352: <br />P304 + P340: <br />P305 + P351 + P338: <br />P308 + P313 <br />P332 + P313: <br />P362:</p> <p>IF ON SKIN: <br />IF INHALED:</p> <p>Wash with plenty of water. <br />Remove victim to fresh air and keep at rest in a position comfortable <br />for breathing. <br />IF IN EYES: <br />Rinse cautiously with water for several minutes. Remove contact <br />lenses, if present and easy to do. Continue rinsing. <br />IF exposed or concerned, get medical advice/attention. <br />IF skin irritation occurs, get medical advice/attention. <br />Take off contaminated clothing and wash before reuse.</p> <p>Page 1 of 5</p> <p>IDENTITY:</p> <p>SAFETY DATA SHEET</p> <p>MORTAR-Crete-CI</p> <p>SDS No. 1.MCC.15</p> <p>Storage: <br />P403 + P232:</p> <p>Store in a well-ventilated place. Protect from moisture.</p> <p>Disposal: <br />P501: <br />P502:</p> <p>Dispose of contents/container to an approved waste disposal site. <br />Refer to manufacturer/supplier for information on recovery/recycling.</p> <p>Section 3 – Composition / Information on Ingredients <br />Product based on cement and mineral filler.</p> <p>Hazardous Components <br />CAS No. <br />Portland Cement <br />65997-15-1 <br />14808-60-7 <br />Crystalline Quartz Silica (SiO2) <br />Anhydrous Calcium Sulfate <br />7778-18-9 <br />Proprietary Formula Enhancing Additives</p> <p>TLV <br />3 <br />10 mg/m <br />3 <br />10 mg/m <br />3 <br />10 mg/m</p> <p>PEL <br />3 <br />5 mg/m <br />3 <br />0.1 mg/m <br />3 <br />15 mg/m</p> <p>Weight % <br />50 - 100 <br />30 - 60 <br />0 - 20</p> <p>There are no additional ingredients present which, within the current knowledge of the supplier and in the <br />concentrations applicable, are classified as hazardous to health or the environment and hence not require reporting <br />in this section.</p> <p>Section 4 – First Aid Measures <br />After Inhalation:</p> <p>Remove subject to fresh air. Administer oxygen if difficulty with breathing. Consult a <br />physician.</p> <p>After Ingestion:</p> <p>Immediately seek medical attention. Do not induce vomiting without medical advice. If <br />conscious, drink plenty of water.</p> <p>After Skin Contact:</p> <p>Instantly wash skin with plenty of soap and water for at least 15 minutes. Wash clothing <br />before reuse. Seek medical attention if symptoms persist.</p> <p>After Eye Contact:</p> <p>Rinse opened eye with plenty of running water for at least 15 minutes, lifting upper and <br />lower eyelids occasionally. Consult physician.</p> <p>Section 5 – Fire Fighting Measures <br />Extinguishing Media:</p> <p>Carbon dioxide (CO2), extinguishing powder, water fog, alcohol-resistant <br />foam.</p> <p>Special Fire Fighting Procedures:</p> <p>As in any fire, wear full protective gear and NIOSH-approved selfcontained breathing apparatus with full face-piece operated in the <br />pressure demand or other positive pressure mode. <br />o</p> <p>Unusual Fire and Explosion Hazards: No unusual fire or explosion hazards. Material can splatter above 212 F <br />o <br />(100 C).</p> <p>Section 6 – Accidental Release Measures <br />Person-related Safety Precautions:</p> <p>Avoid causing dust. Avoid eye and skin contact.</p> <p>Environmental precautions:</p> <p>Prevent material from reaching sewage and drainage systems or bodies <br />of water. <br />Page 2 of 5</p> <p>IDENTITY:</p> <p>SAFETY DATA SHEET</p> <p>MORTAR-Crete-CI</p> <p>Methods for Cleaning up:</p> <p>SDS No. 1.MCC.15</p> <p>Use dry cleanup methods that do not disperse dust into the air. With <br />water, material hydrates to a solid harmless waste. Wear personal <br />protective equipment. Emergency procedures are not required.</p> <p>Section 7 – Handling and Storage <br />Handling:</p> <p>Avoid causing dust. Avoid eye and skin contact. Keep out of reach of children.</p> <p>Storage:</p> <p>Store in a cool, dry enclosed area off the ground in tightly closed containers. Protect against <br />wetness and water. No special measures required against explosion and fires. Store away from <br />foodstuffs.</p> <p>Section 8 – Exposure Controls / Personal Protection <br />Engineering Controls:</p> <p>Use with adequate general and local exhaust ventilation. <br />Washing of the skin in the working area must be possible. <br />Eye-wash bottle must be available.</p> <p>Respiratory Protection:</p> <p>Wear a properly fitted NIOSH approved respirator in poorly ventilated areas <br />and/or if high dust concentrations are encountered.</p> <p>Skin Protection:</p> <p>When installing, wear appropriate protective rubber or plastic gloves to prevent <br />hand-skin exposure. Wear appropriate impervious clothing to prevent skin <br />exposure (long sleeve shirt and long pants).</p> <p>Eye Protection:</p> <p>Wear tightly sealed safety glasses with side shields or goggles. Face shield as <br />necessary.</p> <p>Work/Hygienic Practices:</p> <p>Wash hands before breaks and after work, and before eating, drinking or <br />smoking.</p> <p>Section 9 – Physical and Chemical Properties <br />Physical State: <br />Appearance/Color: <br />Odor: <br />Solubility in water: <br />Boiling Point: <br />Melting Point: <br />Flash Point: <br />Auto ignition: <br />Specific Gravity: <br />pH (in water): <br />VOC Concentration:</p> <p>Powder <br />Cement / gray <br />Weak, characteristic <br />Fully miscible <br />N/A <br />N/A <br />Not combustible <br />N/A <br />approx. 2.9 (relative density) <br />12 – 13 <br />0 g/l</p> <p>Section 10 – Stability and Reactivity <br />Chemical Stability:</p> <p>Stable under normal temperatures and pressures.</p> <p>Conditions to Avoid:</p> <p>Avoid contact with humidity. Product hydrates (hardens) and becomes <br />unusable.</p> <p>Hazardous Decomposition Products: No decomposition if used according to specifications. <br />Hazardous Polymerization:</p> <p>Will not occur. <br />Page 3 of 5</p> <p>IDENTITY:</p> <p>SAFETY DATA SHEET</p> <p>MORTAR-Crete-CI</p> <p>Incompatibilities:</p> <p>SDS No. 1.MCC.15</p> <p>None known.</p> <p>Section 11 – Toxicological Information <br />Acute Inhalation Toxicity: <br />Product <br />Silica, crystalline quartz <br />Portland cement</p> <p>Type <br />LC50 <br />LC50</p> <p>Value <br />no data available <br />no data available</p> <p>Acute Oral Toxicity: <br />Silica, crystalline quartz <br />Portland cement</p> <p>LC50 (Oral) <br />LC50 (Oral)</p> <p>1,300 mg/kg <br />2,000 mg/kg</p> <p>Acute Dermal Toxicity <br />Silica, crystalline quartz <br />Portland cement</p> <p>LC50 (Dermal) <br />LC50 (Dermal)</p> <p>no data available <br />no data available</p> <p>Primary Irritant Effect: <br />• On the skin: <br />• On the eye: <br />• Sensitization:</p> <p>Irritant for skin and mucous membranes <br />Irritant effect <br />No sensitizing effect known.</p> <p>Section 12 – Ecological Information <br />Ecological Information:</p> <p>The unused product is slight water pollutant. Large quantities may be toxic to <br />fish. Do not allow undiluted product or large quantities to reach into waterways <br />or drains.</p> <p>Section 13 – Disposal Considerations <br />Waste Disposal Method:</p> <p>Dispose of in a manner consistent with federal, state and local regulations. Do <br />not dispose together with household garbage. Do not allow product to reach <br />sewage system.</p> <p>Unused Residue or Dry Spillage: Pick up dry material. Possibly reuse depending on amount of contamination. <br />Prevent dust exposure. In case of disposal, harden with water and dispose in <br />accordance to local regulations. <br />Slurries:</p> <p>Allow to harden and dispose of as described above.</p> <p>Container disposal:</p> <p>Completely emptied packaging can be given for recycling.</p> <p>Section 14 – Transport Information <br />RCRA Hazard Class:</p> <p>Non-hazardous</p> <p>USDOT (Domestic Surface) <br />IMDG (Ocean) Hazard Class or Division: <br />IATA/ICAO (Air) Hazard Class or Division: <br />TDG (Canada): <br />UN Number:</p> <p>Not regulated <br />Not regulated <br />Not regulated <br />Not regulated <br />Not listed</p> <p>Page 4 of 5</p> <p>IDENTITY:</p> <p>SAFETY DATA SHEET</p> <p>MORTAR-Crete-CI</p> <p>SDS No. 1.MCC.15</p> <p>Section 15 – Regulatory Information <br />SARA 311/312 (RTK): Hazard Categories: <br />SARA Section 313 Notification: <br />CERCLA:</p> <p>State RTK <br />MA, NJ, PA <br />MA, NJ, PA</p> <p>California Proposition 65:</p> <p>YES <br />YES</p> <p>This product does not contain any ingredients regulated under Section <br />313 of the Emergency Planning and Community Right-to-Know Act of <br />1986 or CFR 372. <br />No CERCLA chemicals exist in this product above reportable <br />concentrations.</p> <p>TSCA Section 12(b) Export Notification: <br />State Regulations:</p> <p>Acute Health: <br />Chronic Health:</p> <p>There are no reportable TSCA 12(b) Chemicals in this product. <br />CAS Number <br />65997-15-1 <br />14808-60-7</p> <p>Chemical name <br />Cement, Portland, chemicals <br />Silica, crystalline quartz</p> <p>Warning – This product contains a chemical known to the State of <br />California to cause cancer, birth defects, or other reproductive harm: <br />CAS 14808-60-7: <br />Silica, crystalline quartz.</p> <p>Section 16 – Other Information <br />(Hazard Rating:</p> <p>0 = Minimal;</p> <p>HMIS III rating: <br />Health: 1* <br />Flammability: 0</p> <p>1 = Slight;</p> <p>2 = Moderate;</p> <p>3 = Serious;</p> <p>4 = Severe; * = Chronic)</p> <p>Physical hazard: 0</p> <p>Abbreviations and acronyms: <br />USDOT: <br />IMDG: <br />IATA: <br />CAS: <br />LC50: <br />LD50:</p> <p>United States Department of Transportation. <br />International Maritime Code for Dangerous Goods. <br />International Air Transport Association. <br />Chemical Abstracts Service (Division of the American Chemical Society). <br />Lethal concentration, 50 percent. <br />Lethal dose, 50 percent.</p> <p>SDS prepared by:</p> <p>Aquafin product safety department.</p> <p>DISCLAIMER: <br />We believe the statements, technical information and recommendations contained herein are reliable, but they are <br />given without warranty or guarantee of any kind, expressed or implied, and we assume no responsibility for any <br />loss, damage, or expense, direct or consequential, arising out of their use. Aquafin shall not be responsible for the <br />use of this product in a manner to infringe on any patent or any other intellectual property rights held by others. <br />END OFsafety <br />MSDS <br />(April 09, 2015) <br />User is responsible for determining appropriate <br />measures and for applying the legislation <br />covering his own <br />activities. We recommend that user makes tests to determine the suitability of a product for its particular purpose <br />prior to use. <br />END OF SDS</p> <p>Page 5 of 5</p> <p>(March 12, 2019)</p>
