SDS_AQUAFIN-2KM_Component-B_Liquid_022023.pdf
5 Pages
1.15 MB
Download
<h1>SDS_AQUAFIN-2KM_Component-B_Liquid_022023.pdf</h1> <p>SAFETY DATA SHEET</p> <p>IDENTITY:</p> <p>AQUAFIN-2K/M (COMPONENT-B - Mixing liquid)</p> <p>Date prepared: <br />Date revised:</p> <p>SDS No. 1.1.3.B</p> <p>APRIL 2000 <br />FEBRUARY 2023 .</p> <p>SDS No.1.1.3.B</p> <p>Section 1 – Product Identification <br />IDENTITY:</p> <p>Product Name:</p> <p>Chemical Characterization: <br />Product Use Description:</p> <p>AQUAFIN-2K/M (Gray or White) <br />Component – B (mixing liquid)</p> <p>Acrylic Copolymer <br />Surface applied concrete waterproofing coating</p> <p>AQUAFIN, INC. <br />505 BLUE BALL RD. #160 <br />ELKTON, MD 21921</p> <p>24 hr Emergency Phone: Chem-Tel (800) 255-3924</p> <p>Recommended use of the chemical and restriction on use:</p> <p>Refer to the product technical data sheet. <br />For industrial and professional users.</p> <p>Information Phone No.</p> <p>info@aquafin.net</p> <p>(410) 392-2300</p> <p>www.aquafin.net</p> <p>Section 2 – Hazards Identification <br />Classification: <br />No need for classification according to GHS criteria for this product. <br />The product does not require a hazard warning label in accordance with GHS criteria. <br />The product is not classified as hazardous pursuant to the provisions set forth In EC Regulation 1272/2008 (CLP).</p> <p>Label elements: <br />Labelling according to Regulation (EC) No 1272/2008 N/A</p> <p>Hazard Pictograms: N/A <br />Signal word: N/A <br />Hazard Statements: N/A <br />Additional Information: <br />EUH208 Contains 1,2-benzisothiazol-3(2H)-one, reaction mass of: 5-chloro-2-methyl-4-isothiazolin3-one [EC no. <br />247-500-7] and 2-methyl-2H-isothiazol-3-one [EC no. 220-239-6] (3:1). May produce an allergic reaction.</p> <p>Page 1 of 5</p> <p>SAFETY DATA SHEET</p> <p>IDENTITY:</p> <p>AQUAFIN-2K/M (COMPONENT-B - Mixing liquid)</p> <p>Disposal: <br />P501: <br />P502:</p> <p>SDS No. 1.1.3.B</p> <p>Dispose of contents/container to an approved waste disposal site. <br />Refer to manufacturer/supplier for information on recovery/recycling.</p> <p>Section 3 – Composition / Information on Ingredients <br />Hazardous Components <br />CAS No. <br />Water based acrylic copolymer dispersion <br />No hazardous components (VOC = 0 g/L)</p> <p>OSHA PEL</p> <p>ACGIH TLV</p> <p>N.A.</p> <p>N.A.</p> <p>Percent</p> <p>There are no additional ingredients present which, within the current knowledge of the supplier and in the <br />concentrations applicable, are classified as hazardous to health or the environment and hence not require reporting <br />in this section.</p> <p>Section 4 – First Aid Measures <br />Inhalation:</p> <p>Supply fresh air and consult a physician in case of symptoms.</p> <p>Ingestion:</p> <p>Drink copious amounts of water and provide fresh air. Consult a physician immediately. <br />Do not induce vomiting without medical advice. If a person vomits, place him/her in the <br />recovery position. Never give anything by mouth to an unconscious person.</p> <p>Skin Contact:</p> <p>Rinse skin with warm water. Seek medical attention if irritation persists. Wash <br />contaminated clothing before reuse</p> <p>Eye Contact:</p> <p>Immediately flush eyes with plenty of water for at least 15 minutes, lifting upper and lower <br />eyelids occasionally and consult a physician.</p> <p>Section 5 – Fire Fighting Measures <br />Auto ignition Temperature:</p> <p>Not combustible.</p> <p>Hazardous combustion Products:</p> <p>Carbon monoxide (CO) <br />Carbon dioxide (CO2)</p> <p>Extinguishing Media:</p> <p>Water, foam, CO2, extinguishing powder or water mist – Product is not <br />combustible.</p> <p>Special Fire Fighting Procedures:</p> <p>In the event of a fire, wear full protective clothing and NIOSH-approved <br />self-contained breathing apparatus with full face-piece operated in the <br />pressure demand or other positive pressure mode.</p> <p>Unusual Fire and Explosion Hazards: Containers can build up pressure if exposed to heat (fire). Cool closed <br />containers exposed to fire with water spray.</p> <p>Section 6 – Accidental Release Measures <br />Measures for Cleaning/Collecting:</p> <p>Wear appropriate protective equipment (see section 8). Contain and <br />collect spillage with absorbent materials, i.e. sand, earth, vermiculite, <br />diatomaceous earth, acid and universal binders, sawdust, and place in <br />container for disposal. Rinse residual stain with water. Prevent material <br />from reaching sewage and drainage systems or bodies of water.</p> <p>Section 7 – Handling and Storage <br />Handling:</p> <p>Avoid contact with skin, eyes and clothing. Keep out of reach of children. Keep away from <br />heat and direct sunlight. Do not store open containers. No special measures required. <br />Page 2 of 5</p> <p>SAFETY DATA SHEET</p> <p>IDENTITY:</p> <p>AQUAFIN-2K/M (COMPONENT-B - Mixing liquid)</p> <p>Storage:</p> <p>SDS No. 1.1.3.B</p> <p>No special storage precautions needed. Store in original container, away from foodstuffs. <br />Store containers tightly closed in a cool (frost free), well ventilated place.</p> <p>Section 8 – Exposure Controls / Personal Protection <br />General Information:</p> <p>Eye-wash bottle must be available. <br />The product does not contain any relevant quantities of materials that have to be <br />monitored at the workplace.</p> <p>Engineering Controls:</p> <p>Provide good (mechanical) room ventilation to control any air contaminants.</p> <p>Respiratory Protection:</p> <p>Not generally required if room is well ventilated. In case of insufficient ventilation <br />wear suitable respiratory equipment. When workers are facing concentrations <br />above the exposure limit they must use NIOSH approved respirators.</p> <p>Skin Protection:</p> <p>When installing, wear appropriate protective gloves (butyl, rubber) to prevent <br />hand-skin exposure. Wear appropriate impervious clothing to prevent skin <br />exposure (long sleeve shirt and long pants).</p> <p>Eye Protection:</p> <p>Wear tightly sealed safety glasses with side shields or goggles. Face shield as <br />necessary.</p> <p>Work/Hygienic Practices:</p> <p>Handle using good industrial hygiene and safety practices. Keep work area clean. <br />Wash hands before breaks and after work, and before eating, drinking or <br />smoking.</p> <p>Section 9 – Physical and Chemical Properties <br />Physical State: <br />Color: <br />Odor: <br />Solubility in water: <br />Flash Point: <br />Lower explosion Limit: <br />Upper explosion Limit: <br />o <br />pH-value at 20 C: <br />Boiling Point: <br />Freezing Point: <br />Specific Gravity (Density): <br />o <br />Viscosity, dynamic at 20 C: <br />VOC Concentration as applied:</p> <p>Milky Liquid <br />White <br />Weak, characteristic like acrylic <br />Fully miscible <br />Not combustible <br />N/A <br />N/A <br />o <br />o <br />7 – 9 at 73 F (23 C) <br />o <br />o <br />212 F (100 C) Water <br />o <br />o <br />32 F (0 C) <br />o <br />o <br />1.05 kg/L at 73 F (23 C) <br />1,800 – 2,500 cps (mPas) <br />0 g/L</p> <p>Section 10 – Stability and Reactivity <br />Thermal Decomposition:</p> <p>No decomposition if used as prescribed.</p> <p>Chemical Stability:</p> <p>Stable under normal temperatures and pressures.</p> <p>Hazardous Polymerization:</p> <p>Will not occur under normal conditions.</p> <p>Incompatibilities:</p> <p>None known.</p> <p>Section 11 – Toxicological Information <br />Product Information: <br />Page 3 of 5</p> <p>SAFETY DATA SHEET</p> <p>IDENTITY:</p> <p>AQUAFIN-2K/M (COMPONENT-B - Mixing liquid)</p> <p>Acute Oral Toxicity: <br />• AQUAFIN-2K/M:</p> <p>SDS No. 1.1.3.B</p> <p>LD/LC50 values that are relevant for classification:</p> <p>No data existing.</p> <p>Primary irritant effect: <br />• On the skin: <br />No irritant effect. <br />• On the eye: <br />No irritant effect. <br />• Sensitization: <br />No sensitizing effect known. <br />• Additional toxicological information: <br />The toxicological data are given by analogy. <br />According to experience, the product is considered to be harmless to health if used in the correct manner. <br />On the basis of the product’s composition, no acute general toxic effects are to be expected. <br />Frequent contact can lead to skin and eye irritation, especially if product is allowed to dry out.</p> <p>Section 12 – Ecological Information <br />Ecological Information:</p> <p>The product is a slight water pollutant. Large quantities may be toxic to <br />fish. Do not empty into waterways and drains.</p> <p>Section 13 – Disposal Considerations <br />Recommendations:</p> <p>Use excess product in an alternate beneficial application. <br />Smaller quantities can be disposed with household garbage. <br />Expose liquid product to fresh air to allow water to evaporate. Remaining cured product <br />becomes a rubbery harmless mass.</p> <p>Disposal:</p> <p>Dispose of in a manner consistent with federal, state and local regulations. Empty <br />containers should be taken to an approved waste handling site for recycling or disposal.</p> <p>Cleaning Solution:</p> <p>Water. If necessary, add cleaning agents (i.e. soap, etc.).</p> <p>RCRA Hazardous Waste:</p> <p>No.</p> <p>RCRA number: NONE.</p> <p>Section 14 – Transport Information <br />DOT (Domestic Surface) Hazard Class or Division: <br />IMO (Ocean) Hazard Class or Division: <br />ICAO (Air) Hazard Class or Division:</p> <p>Not regulated, not dangerous goods. <br />Not regulated, not dangerous goods. <br />Not regulated, not dangerous goods.</p> <p>Section 15 – Regulatory Information <br />TSCA Status:</p> <p>There are no TSCA 12(b) Chemicals in this product.</p> <p>SARA 311/312 Hazard Categories: <br />• Reactive Hazard: <br />No <br />• Pressure Hazard: <br />No <br />• Fire Hazard: <br />No <br />• Immediate/Acute: <br />No <br />• Delayed/Chronic: <br />No <br />SARA 313 Notification:</p> <p>This product contains no toxic chemicals subject to the SARA 313 supplier <br />notification requirements.</p> <p>CERCLA:</p> <p>No CERCLA chemicals exist in this product above reportable concentrations.</p> <p>California Proposition 65:</p> <p>This product does not contain any chemicals known to the State of <br />Page 4 of 5</p> <p>SAFETY DATA SHEET</p> <p>IDENTITY:</p> <p>AQUAFIN-2K/M (COMPONENT-B - Mixing liquid)</p> <p>SDS No. 1.1.3.B</p> <p>California to cause cancer, birth defects, or other reproductive harm:</p> <p>Section 16 – Other Information <br />(Hazard Rating:</p> <p>0 = Minimal;</p> <p>HMIS III rating: <br />Health: 1* <br />Flammability: 1</p> <p>1 = Slight;</p> <p>2 = Moderate;</p> <p>Physical hazard: 0</p> <p>3 = Serious;</p> <p>4 = Severe; * = Chronic)</p> <p>Protection: X</p> <p>Abbreviations and acronyms: <br />USDOT: <br />IMDG: <br />IATA: <br />CAS: <br />LC50: <br />LD50:</p> <p>United States Department of Transportation. <br />International Maritime Code for Dangerous Goods. <br />International Air Transport Association. <br />Chemical Abstracts Service (Division of the American Chemical Society). <br />Lethal concentration, 50 percent. <br />Lethal dose, 50 percent.</p> <p>SDS prepared by:</p> <p>Aquafin product safety department.</p> <p>DISCLAIMER: <br />We believe the statements, technical information and recommendations contained herein are reliable, but they are <br />given without warranty or guarantee of any kind, expressed or implied, and we assume no responsibility for any <br />loss, damage, or expense, direct or consequential, arising out of their use. Aquafin shall not be responsible for the <br />use of this product in a manner to infringe on any patent or any other intellectual property rights held by others. <br />END OFsafety <br />MSDS <br />(April 09, 2015) <br />User is responsible for determining appropriate <br />measures and for applying the legislation <br />covering his own <br />activities. We recommend that user makes tests to determine the suitability of a product for its particular purpose <br />prior to use. <br />END OF SDS</p> <p>Page 5 of 5</p> <p>(February 20, 2023)</p>
