IDENTITY:
SAFETY DATA SHEET
AQUAFIN-IC ADMIX-Liquid
Date prepared: Date revised:
SDS No. 1.4.2.
FEBRUARY 2005 JANUARY 2019
SDS No.1.4.2.
Section 1 – Product Identification IDENTITY:
Product Name:
Chemical Characterization: Product Use Description:
Cement – Preparation Liquid crystalline waterproofing additive / admix for concrete
AQUAFIN, INC. 505 BLUE BALL RD. #160 ELKTON, MD 21921
Emergency Phone No. Information Phone No.
info@aquafin.net
Recommended use of the chemical and restriction on use:
(800) 394-1410 (410) 392-2300
www.aquafin.net
Refer to the product technical data sheet. For industrial and professional users.
Section 2 – Hazards Identification GHS Classification: Skin irritation, Category 2 Serious eye damage, Category 1 Respiratory system; Category 3
H315: Causes skin irritation H318: Causes serious eye damage H335: May cause respiratory irritation
GHS Label element: Hazard Pictograms GHS05
GHS07
Signal Word:
Warning
Hazard Statements: H315: H318: H335:
Causes skin irritation. Causes serious eye damage. May cause respiratory irritation.
Precautionary Statements: Prevention: P264: Wash skin thoroughly after handling. P280: Wear eye protection/face protection. P280: Wear protective gloves. P281: Use protective equipment as required. Response: P302 + P352: P304 + P340: P305 + P351 + P338: P308 + P313 P332 + P313: P362:
IF ON SKIN: IF INHALED:
Wash with plenty of water. Remove victim to fresh air and keep at rest in a position comfortable for breathing. IF IN EYES: Rinse cautiously with water for several minutes. Remove contact lenses if present and easy to do. Continue rinsing. IF exposed or concerned, get medical advice/attention. IF skin irritation occurs, get medical advice/attention. Take off contaminated clothing and wash before reuse.
Page 1 of 5
Storage: P403:
Store in a well-ventilated place.
Disposal: P501: P502:
Dispose of contents/container to an approved waste disposal site. Refer to manufacturer/supplier for information on recovery/recycling.
Section 3 – Composition / Information on Ingredients Components CAS No. TLV Water based solution of inorganic alkaline earth mineral compounds.
PEL
Weight % 10 - 30
There are no additional ingredients present which, within the current knowledge of the supplier and in the concentrations applicable, are classified as hazardous to health or the environment and hence not require reporting in this section.
Section 4 – First Aid Measures After Inhalation:
Remove subject to fresh air. Administer oxygen if difficulty with breathing. Consult a physician.
After Ingestion:
Immediately seek medical attention. Do not induce vomiting without medical advice. If conscious, drink plenty of water.
After Skin Contact:
Instantly wash skin with plenty of soap and water for at least 15 minutes. Wash clothing before reuse. Seek medical attention if symptoms persist.
After Eye Contact:
Rinse opened eye with plenty of running water for at least 15 minutes, lifting upper and lower eyelids occasionally. Consult physician.
Section 5 – Fire Fighting Measures Extinguishing Media:
Carbon dioxide (CO2), extinguishing powder, water fog, alcohol-resistant foam.
Special Fire Fighting Procedures:
As in any fire, wear full protective gear and NIOSH-approved selfcontained breathing apparatus with full face-piece operated in the pressure demand or other positive pressure mode. o
Unusual Fire and Explosion Hazards: No unusual fire or explosion hazards. Material can splatter above 212 F o (100 C).
Section 6 – Accidental Release Measures Person-related Safety Precautions:
Avoid eye and skin contact.
Environmental precautions:
Prevent material from reaching sewage and drainage systems or bodies of water.
Methods for Cleaning up:
Use dry cleanup methods. Wear personal protective equipment. Emergency procedures are not required.
Section 7 – Handling and Storage Handling:
Avoid eye and skin contact. Keep out of reach of children. Page 2 of 5
Storage:
Store in a cool, dry enclosed area off the ground in tightly closed containers. No special measures required against explosion and fires. Store away from foodstuffs.
Section 8 – Exposure Controls / Personal Protection Engineering Controls:
Use with adequate general and local exhaust ventilation. Washing of the skin in the working area must be possible. Eye-wash bottle must be available.
Respiratory Protection:
Wear a properly fitted NIOSH approved respirator in poorly ventilated areas.
Skin Protection:
When installing, wear appropriate protective rubber or plastic gloves to prevent hand-skin exposure. Wear appropriate impervious clothing to prevent skin exposure (long sleeve shirt and long pants).
Eye Protection:
Wear tightly sealed safety glasses with side shields or goggles. Face shield as necessary.
Work/Hygienic Practices:
Wash hands before breaks and after work, and before eating, drinking or smoking.
Section 9 – Physical and Chemical Properties Physical State: Color: Odor: Solubility in water: Boiling Point: Melting Point: Flash Point: Auto ignition: Bulk Density: pH (in water): Viscosity, dynamic: VOC Concentration:
Liquid Transparent / blue Odorless Miscible o o 100 C (212 F) N/A Not combustible N/A 3 approx. 1.15 kg/dm 11 – 13.5 (Alkaline) o o 4 – 7 mPas (4-7 cps) Brookfield-LV #61/100 RPM at 20 C (68 F) 0 g/l
Section 10 – Stability and Reactivity Chemical Stability:
Stable under normal temperatures and pressures.
Conditions to Avoid:
Exposure to low temperature and freezing.
Hazardous Decomposition Products: No decomposition if used according to specifications. Hazardous Polymerization:
Will not occur.
Incompatibilities:
None known.
Section 11 – Toxicological Information Acute Inhalation Toxicity:
LD50
2,800 mg/kg (rat)
Acute Dermal Toxicity:
>2,000 mg/kg (rabbit)
Primary Irritant Effect: Page 3 of 5
• • •
On the skin: On the eye: Sensitization:
Irritant for skin and mucous membranes Irritant/corrosive effect No sensitizing effect known.
Section 12 – Ecological Information Ecological Information:
The unused product is slight water pollutant. Large quantities may be toxic to fish. Do not allow undiluted product or large quantities to reach into waterways or drains.
Section 13 – Disposal Considerations Waste Disposal Method:
Dispose of in a manner consistent with federal, state and local regulations. Do not dispose together with household garbage. Do not allow product to reach sewage system.
Unused Residue or Spillage: Pick up wet or dry material. In case of disposal, harden liquid material with cement or concrete and dispose in accordance to local regulations. Container disposal:
Completely emptied packaging can be given for recycling.
Section 14 – Transport Information RCRA Hazard Class:
Non-hazardous
USDOT (Domestic Surface) IMDG (Ocean) Hazard Class or Division: IATA/ICAO (Air) Hazard Class or Division: TDG (Canada): UN Number:
Not regulated Not regulated Not regulated Not regulated Not listed
Section 15 – Regulatory Information SARA 311/312 (RTK): Hazard Categories: SARA Section 313 Notification: CERCLA:
State RTK MA, NJ, PA
California Proposition 65:
YES YES
This product does not contain any ingredients regulated under Section 313 of the Emergency Planning and Community Right-to-Know Act of 1986 or CFR 372. No CERCLA chemicals exist in this product above reportable concentrations.
TSCA Section 12(b) Export Notification: State Regulations:
Acute Health: Chronic Health:
There are no reportable TSCA 12(b) Chemicals in this product. CAS Number ---------
Chemical name ---------
This product does not contain a chemical known to the State of California to cause cancer, birth defects, or other reproductive harm.
Section 16 – Other Information (Hazard Rating:
0 = Minimal;
1 = Slight;
2 = Moderate;
Page 4 of 5
3 = Serious;
4 = Severe; * = Chronic)
HMIS III rating: Health: 1* Flammability: 0
Physical hazard: 0
Abbreviations and acronyms: USDOT: IMDG: IATA: CAS: LC50: LD50:
United States Department of Transportation. International Maritime Code for Dangerous Goods. International Air Transport Association. Chemical Abstracts Service (Division of the American Chemical Society). Lethal concentration, 50 percent. Lethal dose, 50 percent.
SDS prepared by:
Aquafin product safety department.
DISCLAIMER: We believe the statements, technical information and recommendations contained herein are reliable, but they are given without warranty or guarantee of any kind, expressed or implied, and we assume no responsibility for any loss, damage, or expense, direct or consequential, arising out of their use. Aquafin shall not be responsible for the use of this product in a manner to infringe on any patent or any other intellectual property rights held by others. END OFsafety MSDS (April 09, 2015) User is responsible for determining appropriate measures and for applying the legislation covering his own activities. We recommend that user makes tests to determine the suitability of a product for its particular purpose prior to use. END OF SDS
Page 5 of 5
(January 22, 2019)