EPOXY-N161 (Novolac) COMPONENT B - SAFETY DATASHEET SECTION 1: PRODUCT AND COMPANY IDENTIFICATION PRODUCT NAME: SYNONYMS: PRODUCT CODES:
EPOXY-N161 (Novolac)
Part: B
MANUFACTURER: ADDRESS:
Aquafin Inc. 505 Blue Ball Rd., #160 Elkton, MD 21921 +1-410-392-2300
EMERGENCY PHONE: Chemtrec:
PHONE: RECOMENDED USE:
(800) 255-3924
Epoxy Resin, For further information refer to the Product Data Sheet.
SECTION 2: HAZARDS IDENTIFICATION GHS Hazard:
ROUTES OF ENTRY: SIGNAL WORD:
EYES:
YES
SKIN:
INGESTION:
INHALATION:
DANGER!
HEALTH HAZARDS (ACUTE AND CHRONIC) Serious Eye Damage Cat. 2. EYES: Eye irritation Cat. 2 Acute Dermal Toxicity Cat.4 SKIN: Skin Irritant Cat. 2 Skin Sensitization Cat. 1. Skin Corrosion Cat. 1B Acute Oral Toxicity Cat. 4 INGESTION: INHALATION:
Acute Toxicity Cat 4
ENVIRONMENTAL HAZARDS: Acute Aquatic Cat.1 Chronic Aquatic Cat.1 Acute Toxicity Cat.4 HAZARD STATEMENTS: H302+H312+H332 - Harmful if swallowed, inhaled or in contact with skin H314 - Causes severe skin burns and eye damage H315 - Causes skin irritation H317 - May cause am allergic skin reaction H318 - Causes serioius eye damage H332 - Harmful if inhaled PRECAUTIONARY STATEMENTS: P201 - Obtain special instructions before use P202 - Do not handle until all safety regulations have been read and understood. P261 - Avoid breathing dust/fume/gas/mist/vapors/spray. P264 - Wash…thoroughly after handling with soap and water P270 - Do not eat, drink or smoke when using this product. P271 - Use only outdoors or in a well-ventilated area P273 - Avoid release to the environment P280 - Wear Protective gloves/protective clothing/eye protection/face protection P301+P312 - IF SWALLOWED Call a POISON CENTER or doctor/physician if you feel unwell. P301+P330+P331 - IF SWALLOWED rinse mouth. DO NOT induce vomiting. P304+P340 - IF INHALED Remove victim to fresh air and keep at rest in a position comfortable for breathing. P303+P361+P353 - If ON SKIN (or hair): Remove/ take off immediately all contaminated clothing. Rinse skin with
EPOXY-N161 (Novolac)-b SDS DATE: 22-Dec-14
PAGE 1 OF 6
EPOXY-N161 (Novolac) COMPONENT B - SAFETY DATASHEET water/shower. P305+P351+P338 - IF IN EYES Rinse cautiously with water for several minutes. Remove contact lenses if present and easy to do. Continue rinsing. P333+P313 - If skin irritation or rash occurs: Get medical advice/attention. P363 - Wash contaminated clothing before reuse. P370+P378 - In case of fire: Use dry sand, dry chemical or alcohol-resistant foam for extinction. P391 - Collect spillage. P403+P235 - Store in a well-ventilated place. Keep cool. P405 - Store locked up. P501 - Dispose of contents/container to an approved waste disposal plant. MEDICAL CONDITIONS GENERALLY AGGRAVATED BY EXPOSURE: Persons with preexisting skin or respiratory disorders may have their conditions aggravated by over exposure to this material. This product is not for use in an aerosol or spray. This product contains a component that is toxic by inhalation when aerosolized or sprayed. Refer to Section 11 of the SDS for toxicity information. Review the toxicity information against your intended use. If product is not being aerosolized or sprayed, inhalation toxicity is not applicable. SECTION 3: COMPOSITION/INFORMATION ON INGREDIENTS
HAZARDOUS COMPONENTS
CAS #:
CAL-OSHA PEL TWA (8hours)
ACGIH TLV TWA (8 hours)
Other Limits RECOMMENDED
% BY WEIGHT
2,2'-iminodiethylamine
111-40-0
No Data
30-50
Benzenediamine, ar, ar-diethyl-ar-methyl-
68479-98-1
2-sec-BUTYLPHENOL
89-72-5
SECTION 4: FIRST AID MEASURES EYES: SKIN: INGESTION: INHALATION:
Immediately flush eyes with water for a minimum of 15 minutes while holding eyes open. Remove contact lenses if present and easy to do. If redness, burning, blurred vision, or swelling persists, consult a physician. Remove contaminated clothing and product. Immediately wash affected area with soap and water. Do not apply greases or ointments. If skin irritation persists, consult a physician. Rinse mouth immediately. Give small amounts of water, only if person is conscious. Only induce vomiting at the instruction of medical personnel. consult a physician Remove patient to fresh air. Give oxygen or artificial respiration if needed. If patient continues to experience difficulty breathing, consult a physician. Call Poison Center
SECTION 5: FIRE-FIGHTING MEASURES SUITABLE EXTINGUISHING MEDIA: SPECIAL FIRE FIGHTING PROCEDURES:
HAZARDOUS DECOMPOSITION PRODUCTS:
FLASH POINT: METHOD USED:
Extinguish with foam, carbon dioxide, dry powder, or water fog. Use standard fire-fighting procedures and consider the hazards of other involved materials. In case of a fire and / or explosion do not breathe fumes. Self-contained breathing apparatus and full protective clothing must be worn. Move containers from fire area if you can do so without risk. Cool containers with flooding quantities of water until well after fire is out. Prevent runoff from fire control or dilution from entering streams, sewers, or drinking water supply. Hazardous decomposition products may occur when material polymerizes at temperatures above 500 oF (260 oC). Irritating and toxic gases/fumes may be released during a fire. Do not allow run-off from fire-fighting to enter drains or water courses.
205 oF / 96 oC (TCC)
PAGE 2 OF 6
EPOXY-N161 (Novolac) COMPONENT B - SAFETY DATASHEET SECTION 6: ACCIDENTAL RELEASE MEASURES PERSONAL PROTECTION:
ACCIDENTAL RELEASE MEASURES: WASTE DISPOSAL:
Keep unnecessary personnel away. Eliminate all ignition sources (no smoking, flares, sparks, or flames in immediate area). Wear appropriate personal protective equipment. Do not touch containers or spilled material unless wearing appropriate protective clothing. Avoid inhalation of vapors or mists. Ensure adequate ventilation. Local authorities should be advised if significant spillage cannot be contained. In case of spill, clean up using absorbent material such as earth or sand. Small quantities can be wiped up with cloth, place cloth in leak proof container and dispose of properly. Observe Federal, State and local regulations covering chemical waste spills.
SECTION 7: HANDLING AND STORAGE PERSONAL PROTECTION: HANDLING AND STORAGE:
Use personal protective equipment to ensure product does not contact eyes or skin when handling materials. Store in cool dry place out of direct sunrays. Keep from freezing. Recommend storage temperatures range: between 40o and 95 oF (4o - 35 oC)
SECTION 8: EXPOSURE CONTROLS/PERSONAL PROTECTION PROTECTIVE MEASURE: EYE PROTECTION: HAND PROTECTION: SKIN AND BODY PROTECTION: RESPIRATORY PROTECTION:
WORK HYGIENIC PRACTICES:
ENGINEERING CONTROLS:
Wear appropriate personal protective equipment. Wear appropriate safety glasses with side shields, goggles or full face shield. When working on an overhead application a full face shield is recommended. Wear chemical-resistant gloves such as: Nitrile, neoprene, butyl. Wear long sleeve shirts/long pants and other clothing as required to minimize contact. Do not breathe gas/fumes/vapor/ or spray. The use of a respirator is not required during general use of this product provided adequate ventilation. If grinding or cutting cured product the use of an approved respirator is recommended. Always observe good personal hygiene measures, such as washing after handling the material and before eating, drinking and/or smoking. Routinely wash work clothing and protective equipment to remove contaminants. When using indoors, good ventilation (typically 10 air changes per hour) should be used. Ventilation rates should be matched to conditions. Ready access to running water is required. Provide eyewash station.
EXPOSURE LIMITS Component 2,2'-iminodiethylamine 111-40-0 Benzenediamine, ar, ar-diethyl-ar-methyl68479-98-1 2-sec-BUTYLPHENOL – 89-72-5
OSHA (PEL)
ACGIH (TLV)
NIOSH (Pocket Guide)
TWA 5 ppm
TWA 30mg/m3
PAGE 3 OF 6
EPOXY-N161 (Novolac) COMPONENT B - SAFETY DATASHEET SECTION 9: PHYSICAL AND CHEMICAL PROPERTIES APPEARANCE: ODOR: PHYSICAL STATE: pH AS SUPPLIED: BOILING POINT: MELTING POINT: FREEZING POINT: VAPOR PRESSURE (mm Hg): VAPOR DENSITY (AIR = 1): SPECIFIC GRAVITY (H2O = 1): EVAPORATION RATE: SOLUBILITY IN WATER: PERCENT SOLIDS BY WEIGHT: PERCENT VOLATILE: VOLATILE ORGANIC COMPOUNDS (VOC): MOLECULAR WEIGHT: VISCOSITY:
Amber liquid Ammonia Liquid Alkaline ND N/D N/D 1 mmHg 20C (DETA) Heavier than air 1.0 Negligible Slight No Data Negligible No Data N/D 1400 cp.
SECTION 10: STABILITY AND REACTIVITY STABILITY: CONDITIONS TO AVOID (STABILITY): INCOMPATIBILITY (MATERIAL TO AVOID): HAZARDOUS DECOMPOSITION OR BYPRODUCTS: HAZARDOUS POLYMERIZATION:
Stable Exposure to excessive heat and open flame Strong acids, peroxides and other oxidizing agents. Normal combustion forms carbon dioxide, carbon monoxide, oxides of carbon and other organic compounds, Will not occur
SECTION 11: TOXICOLOGICAL INFORMATION CAS# Acute Oral Toxicity: No data available on the product itself 2,2'-iminodiethylamine 111-40-0 LD50: Oral Rat: 1080 mg/kg Benzenediamine,ar, ar-diethyl-ar68479-98-1 LD50: Oral Rat: 738 mg/kg methyl2-sec-BUTYLPHENOL – 89-72-5 LD50: Oral Rat: 200-2000 mg/kg (OECD 401) Acute Dermal Toxicity: No data available on the product itself 2,2'-iminodiethylamine 111-40-0 LD50 1090 mg/kg Species: Rabbit LD50 Dermal Rabbit M : >2000 mg/kg Benzenediamine,ar, ar-diethyl-ar68479-98-1 methylLD50 Dermal Rabbit : 5560 mg/kg 2-sec-BUTYLPHENOL – 89-72-5 Acute Inhalation Toxicity: No data available on the product itself Inhalation/toxicity Components 2,2'-iminodiethylamine 111-40-0 LC50 4 hours – 0.3mg/l Species: Rat Carcinogenicity: This product contains no listed carcinogens according to IARC, ACGIH, NTP and/or OSHA in concentrations of 0.1 percent or greater. No data ACGIH: No data IARC: No data NTP No data OSHA
PAGE 4 OF 6
EPOXY-N161 (Novolac) COMPONENT B - SAFETY DATASHEET SECTION 12: ECOLOGICAL INFORMATION ECOTOXICITY: Aquatic toxicity: Toxicity to Fish-Components 2,2'-iminodiethylamine Benzenediamine,ar, ar-diethyl-armethyl2-sec-BUTYLPHENOL – Toxicity to algae-Components 2,2'-iminodiethylamine Benzenediamine,ar, ar-diethyl-armethyl2-sec-BUTYLPHENOL – Toxicity-Aquatic Invertebrates 2,2'-iminodiethylamine Benzenediamine,ar, ar-diethyl-armethyl2-sec-BUTYLPHENOL – PERSISTENCE & DEGRADABILITY: BIODEGRADABILITY: 2,2'-iminodiethylamine Benzenediamine,ar, ar-diethyl-armethyl2-sec-BUTYLPHENOL – BIOACCUMULATIVE POTENTIAL: MOBILITY IN SOIL: OTHER ADVERSE EFFECTS: AQUATIC RELEASE:
CAS# Exposure at low concentrations my kill fish 111-40-0 68479-98-1
NA LC50(96hr): 104 mg/l Species: Fathead Minnow
LC50(96hr): 0.05 mg/l Species: Fish
111-40-0 68479-98-1
NA EC50(72hr): 104 mg/l Species: Algae
EC50(72hr): 10 mg/l Species: Algae
NA EC50(48hr): 5.8 mg/l Species: Daphnia
EC50(48hr): 3.7 mg/l Species: Daphnia
NA Not readily biodegradable
Biodegrades Slowly NA Yes NDA Advise authorities if product has entered or may enter watercourses or sewer drains.
SECTION 13: DISPOSAL CONSIDERATIONS WASTE DISPOSAL METHOD:
Do not allow this material to drain into sewers / waterways, ditches, containment pools or water supplies. Dispose of contents / containers in accordance with local/regional/international regulations.
PAGE 5 OF 6
EPOXY-N161 (Novolac) COMPONENT B - SAFETY DATASHEET SECTION 14: TRANSPORT INFORMATION U.S. DEPARTMENT OF TRANSPORTATION (DOT) PROPER SHIPPING NAME: HAZARD CLASS: ID NUMBER: PACKING GROUP:
Polyamines, Liquid, Corrosive, n.o.s. (Diethylenetriamine) 8 UN2735 II
WATER TRANSPORTATION (IMDG) PROPER SHIPPING NAME: HAZARD CLASS: ID NUMBER: PACKING GROUP:
Polyamines, Liquid, Corrosive, n.o.s. (Diethylenetriamine), Marine Pollutant 8 UN2735 II
AIR TRANSPORTATION (IATA / ICAO) PROPER SHIPPING NAME: HAZARD CLASS: ID NUMBER: PACKING GROUP:
Polyamines, liquid, corrosive, n.o.s. (Diethylenetriamine) 8 UN2735 II
SECTION 15: REGULATORY INFORMATION U.S. FEDERAL REGULATIONS TSCA (TOXIC SUBSTANCE CONTROL ACT): CERCLA (COMPREHENSIVE RESPONSE COMPENSATION, AND LIABILITY ACT): OSHA: WHMIS
Not Listed 29 CFR 1910.1200 (Hazard Communication required) Class D: Corrosive, Div.2, Sub. A&B; Class E
SARA TITLE III (SUPERFUND AMENDMENTS AND REAUTHORIZATION ACT): No 302/304 Acute Health Hazard: 311/312 HAZARD CATEGORIES: Chronic Health Hazard: Fire Hazard: Pressure Release Hazard: Reactivity Hazard: None 313 REPORTABLE INGREDIENTS:
Yes Yes No No No
STATE REGULATIONS: CALIFORNIA PROPOSITION 65 (THE SAFE DRINKING WATER AND TOXICS ENFORCEMENT ACT) This product contains chemicals in trace quantities that are on the California Proposition 65 carcinogens list. SECTION 16: OTHER INFORMATION HAZARDOUS MATERIALS IDENTIFICATION SYSTEM HMIS HAZARD RATING 3 HEALTH 1 FLAMMABILITY 1 REACTIVITY C PERSONAL PROTECTION 4 – Severe, 3 – Serious, 2 – Moderate, 1 - Slight C – (Safety glasses, gloves, apron) The information provided herein was believed by Aquafin Inc. to be accurate at the time of preparation or prepared from sources believed to be reliable, but it is the responsibility of the user to investigate and understand other pertinent sources of information, to comply with all laws and procedures applicable to the safe handling and use of product and to determine the suitability of the product for its intended use.
PAGE 6 OF 6