SAFETY DATA SHEET
SDS No. I.SF.2
IDENTITY: InjectPro-SuperFast: Component-B
SDS No. I.SF.2
Section 1 – Product Identification
Product Use Description:
Polyurethane Injection Grout
505 BLUE BALL RD. #160
ELKTON, MD 21921
24 hr Emergency Phone: Chem-Tel
Recommended use of the chemical and restriction on use:
Refer to the product technical data sheet.
For industrial and professional users.
Information Phone No.
Section 2 – Hazards Identification
Skin irritation, Category 2
Serious eye damage, Category 1
Specific target organ toxicity, repeated exposure, Category 2
GHS Label element:
Causes skin irritation.
Causes serious eye damage.
May cause damage to respiratory system through prolonged or repeated exposure.
Keep out of reach of children.
Do not breathe mist, vapours or spray.
Wash skin thoroughly after handling.
Do not eat, drink or smoke when using this product.
Wear protective gloves/protective clothing/eye protection/face protection.
P302 + P352:
P332 + P313:
P305 + P351 + P338:
P337 + P313
IF ON SKIN:
Wash with plenty of soap and water.
IF SKIN irritation occurs, get medical attention.
Take off contaminated clothing and wash before reuse.
IF IN EYES:
Rinse cautiously with water for several minutes. Remove contact
lenses, if present and easy to do. Continue rinsing.
IF eye irritation persists, get medical advice/attention.
Immediately call a POISON CENTER or physician.
Get medical attention if you feel unwell.
Page 1 of 5
SAFETY DATA SHEET
P403 + P410:
Store in a well-ventilated place. Protect from sunlight.
Dispose of contents/container to an approved waste disposal site.
Section 3 – Composition / Information on Hazardous Ingredients
Non-hazardous polyether polyols
50 - 70
Note: There are no additional ingredients present which, within the current knowledge of the supplier and in the
concentrations applicable, are classified as hazardous to health or the environment and hence require reporting in
Section 4 – First Aid Measures
Supply fresh air and consult a physician if breathing becomes difficult. Symptoms may be
delayed for several hours.
If person is conscious, wash out mouth with water. Do not induce vomiting unless
instructed to do so by a poison center or physician.
Immediately flush skin with plenty of water. Do not use solvents or thinners. Remove
contaminated clothing and shoes. Seek medical advice if irritation or rash occurs. Wash
clothing before reuse.
Immediately flush eyes with plenty of water for at least 15 minutes, lifting upper and lower
eyelids occasionally. Remove contact lenses, if present. Seek medical attention if irritation
Section 5 – Fire Fighting Measures
Water spray, foam, dry chemical or carbon dioxide.
Fire Fighting Procedures:
Standard. As in any fire, wear self-contained breathing apparatus
pressure-demand, MSHA/NIOSH (approved or equivalent) and full
protective gear. Containers can build up pressure if exposed to heat
(fire). Cool with water spray. Do not scatter material with high pressure
Hazardous Combustion Products:
Carbon oxides, nitrogen oxides, and various hydrocarbons.
Section 6 – Accidental Release Measures
Person-related Safety Precautions:
Provide plenty of fresh air. Avoid eye and skin contact. Avoid inhalation
of vapors. Wear personal protective equipment. Remove or eliminate all
Methods for cleaning-up:
Prevent from entering into soil, ditches, sewers, waterways and/or
groundwater. Small spills: Absorb with dry chemical absorbent, earth,
Page 2 of 5
sand or any other inert material. Clean spill area with detergent and
water. Retain water for disposal.
Waste Disposal Method:
Dispose in accordance with local, state and federal regulations.
Do not allow product to reach ground water, bodies of water, or storm
water or sewage systems.
Section 7 – Handling and Storage
Avoid contact with eyes, skin and clothing. Wash thoroughly after handling.
Follow all SDS/label precautions even after the container is emptied because it
may retain product residues. Use only with adequate ventilation. Keep container
closed when not in use. Do not reseal if contaminated. Keep away from heat and
Keep container tightly closed when not in use. Do not store in direct sunlight.
4oC – 32oC (~40oF - ~90oF).
Section 8 – Exposure Controls / Personal Protection
Use adequate ventilation.
Wear chemical resistant protective clothing and footwear impervious to the
product if there is a potential for skin contact.
Use safety goggles or face shield.
Wash hands before breaks and after work, and before eating, drinking or
Section 9 – Physical and Chemical Properties
Solubility in water:
Specific Gravity (water = 1) at 25oC:
Viscosity, (kinematic) at 25oC:
Auto ignition Temperature:
Lower explosion Limit:
Upper explosion Limit:
Insoluble, reacts with water
>93°C (>200°F) (closed cup)
1.12 – 1.14 g/cm3
1500 - 2000 cps
No data available
No data available
No data available
Section 10 – Stability and Reactivity
Hazardous Decomposition Products: Carbon oxides, nitrogen oxides and various hydrocarbons.
Page 3 of 5
Will not occur.
Strong acids, bases and oxidizers.
Section 11 – Toxicological Information
11890 mg/kg (rabbit).
12565 mg/kg (rat).
> 4.4 mg/L/4 h (rat).
290 mg/L/6 h
IARC: Not regulated as a carcinogen.
NTP: Not regulated as a carcinogen.
OSHA: Not regulated as a carcinogen.
Section 12 – Ecological Information
>32,000 mg/L/96h (fish)
>22 mg/L/96h (golden orfe)
>84,770 mg/L/48 h (daphnia).
>76 mg/L/48 h (daphnia).
Section 13 – Disposal Considerations
Must be disposed of in a manner consistent with federal, state and local regulations.
when cartridge is empty dispose with trash.
RCRA/EPA Waste Information: If discarded in its purchased form, this material is not a RCRA hazardous waste.
Section 14 – Transport Information
USDOT (Domestic Surface):
Section 15 – Regulatory Information
TSCA (Toxic Substances Control Act):
All components are on TSCA inventory.
If discarded in its purchased form, this material is not a RCRA hazardous waste.
US Federal Regulatory Information:
SARA Title III (Superfund Amendments and Reauthorization Act:
311/312 Hazard Categories:
313 Reportable Components:
Page 4 of 5
Section 16 – Other Information
Abbreviations and acronyms:
United States Department of Transportation.
International Maritime Code for Dangerous Goods.
International Air Transport Association.
Chemical Abstracts Service (Division of the American Chemical Society).
Lethal concentration, 50 percent.
Lethal dose, 50 percent.
Median effective concentration.
SDS prepared by:
Aquafin product safety department.
We believe the statements, technical information and recommendations contained herein are reliable, but they are
given without warranty or guarantee of any kind, expressed or implied, and we assume no responsibility for any
loss, damage, or expense, direct or consequential, arising out of their use. Aquafin shall not be responsible for the
use of this product in a manner to infringe on any patent or any other intellectual property rights held by others.
User is responsible for determining appropriate safety measures and for applying the legislation covering his own
activities. We recommend that user makes tests to determine the suitability of a product for its particular purpose
prior to use.
END OF SDS
Page 5 of 5
(March 21, 2019)